Windshield Washer Reservoir Woes | FerrariChat

Windshield Washer Reservoir Woes

Discussion in 'Mondial' started by Russ Gould, Jul 10, 2012.

This site may earn a commission from merchant affiliate links, including eBay, Amazon, Skimlinks, and others.

  1. Russ Gould

    Russ Gould Formula 3

    Nov 8, 2004
    1,073
    #1 Russ Gould, Jul 10, 2012
    My reservoir spewed its contents today. Seems that the retaining washer (copper) inside the bottle gave up and the pump assy came loose. Any sources for said washer? Also, I found a corroded black rubby stopper assy inside that I asssume is the sensor for the idiot light. Don't really care if that's not available but if it is, I suppose it should be put right. Any leads on said parts?
     
  2. fdekeu

    fdekeu Formula Junior

    Jun 19, 2008
    582
    Belzium
    Full Name:
    Frank
    #2 fdekeu, Jul 15, 2012
    Russ,

    I had the pump assy leaking too
    Repaired it by using silicone sealant
    Has been fine for the last 2 yrs

    Only available as a complete unit (not including level sensor though)
    Under 100$ at eurospares so that is an option too
     
  3. Russ Gould

    Russ Gould Formula 3

    Nov 8, 2004
    1,073
    #3 Russ Gould, Jul 23, 2012
    The broken retaining washer is called a "biting washer" aka a "push nut" ... it's made of some kind of copper or perhaps brass alloy .... it holds the pump in place. I am going to try to make one, as while this is a common hardware item, it is not available in this large diameter.
     
  4. ronfrohock

    ronfrohock F1 Rookie
    Owner Rossa Subscribed

    Aug 16, 2004
    3,939
    MA
    Full Name:
    Ron Frohock
    #4 ronfrohock, Jul 23, 2012
    Check McMaster.com for the washer.
    Ron Frohock
     
  5. deeprivergarage

    deeprivergarage Formula Junior
    Owner Rossa Subscribed

    Oct 3, 2009
    560
    S of Fort Worth
    Full Name:
    Jerry
    #5 deeprivergarage, Jul 23, 2012
    Last edited: Jul 23, 2012
    Russ.

    I had to repair one a Mondial some time ago.

    I looked at washer pumps on eBay until I found a similar looking pump. I think it was a Chrysler type that matched the best. There were several that seemed to look the same.

    I then bought a new pump locally and replaced the pump in the reservoir. The pump type/design is fairly universal.

    There are also repair kits available on eBay.

    The float is for the warning light. I found one on eBay.

    There was also a new tank w/pump on eBay a while back. Looked the same, but listed for a F40 or something.

    Good luck.

    DRG

    eBay: Ferrari Part NEW WASHER BOTTLE FOR 512BBi & 288 GTO @ T Rutlands West
     

Share This Page